On water service ...


    TURBOSTAR MIXER

 



General
The TurboStar Mixer is used to mix wastewater in lagoons, equalization and activated sludge tanks. It provides for the circulation and through mixing of wastewater in basins.

Description
The TurboStar Mixer essentially consists of an air-cooled electric motor in mounting position B 35, a coupling, a shaft and a three-blade propeller. The shaft rotates at motor speed inside a protective tube, which is flange mounted to the motor. The protective tube prevents the formation of spray water. The unit is foot mounted on a flotation or a mounting bracket. For vertical installation the TurboStar Mixer can be fitted with motors in mounting position B5, too. Then, a protective tube is not necessary.

Materials and design
The TurboStar Mixer is of simple design and is very sturdy. It is made of non-corrosive materials. Standard material for the shaft, the propeller and all the small parts in stainless steel AISI 304, which is sufficient in most cases. On special request stainless steel AISI 316 Ti is available as well. The protective tube is made of GRP.
The electric motors are supplied by leading manufacturers in the European Community (AEG, EMOD, VEM). They are highly efficient, adequately rated and provided with permanently lubricated grooved ball bearings. The motor housings are made of high-quality cast iron or aluminium with an additional coat of protective paint.
The drive and the hollow shaft are attached by means of a special coupling, which can easily be assembled and disassembled. This precision-turned component is produced on numerically controlled machines. An extruded seamless steel tube with tight production tolerances is used for the shaft. Dynamic balancing of the shaft assembly in conjunction with the motors ensures smooth operation.
The immersion section does not contain any seals or bearings. Consequently, the machine is almost maintenance-free.
The TurboStar Mixer represents the international quality standard of wastewater management which is based on producers TÜV CERT according to ISO 9002.

Wide-Ranging Applications
The TurboStar Mixer is an outstanding unit for effective mixing not only of municipal and industrial wastewater but also for waste sludge in holding tanks.
In addition, the TurboStar Mixer is ideal for upgrading, retrofitting or replacing mixing equipment no longer operating at an optimal level.

Installation
Every TurboStar Mixer can be handled easily due to its low weight. In lagoons or equalization basins the TurboStar Mixer is preferably installed on sturdy flotations fixed on the bank with mooring cables.
The flotation for a TurboStar Mixer essentially consists of two resp. three tanks and hot-dip galvanized framework. The tanks are made of GRP and filled with polyurethane foam so that the flotations are unsinkable.
In concrete basins with constant water level the TurboStar Mixer is usually fixed with mounting brackets to a bridge or a sidewall.

Technical data
The TurboStar Mixer is available in all IEC motor sizes from 0.75HP 50.55kW) to 20hp (150.0kW).
Standard motors are 230/400 V resp. 400/690 V, 50 Hz, 3-phase. Different voltage and 60 Hz are available, too. Motor speed is = 1.000 r.p.m. At 50 Hz resp. = 1.200 r.p.m. At 60 Hz.

Type
Nominal power kW
Nominal current A
Consumed power kW
Speed r.p.m.
Weight kg
Length mm
Immersion depth ˜ m
TS 0.55
0.55
1.6
0.7
910
21
1.400
0.4
TS 0.75
0.75
2.2
0.9
915
23
1.400
0.4
TS 1.1
1.1
3.2
1.4
910
27
1.450
0.4
TS 1.5
1.5
3.9
1.7
950
31
1.450
0.5
TS 2.2
2.2
5.4
2.5
950
47
1.550
0.5
TS 3.0
3.0
6.6
3.4
950
68
1.750
0.6
TS 4.0
4.0
9.0
4.5
955
75
1.750
0.6
TS 5.5
5.5
11.5
5.8
955
98
1.800
0.6
TS 7.5
7.5
15.5
7.8
955
122
2.150
0.7
TS 15.0
15.0
30.5
15.0
965
215
2.300
0.8

Other voltages and frequencies as well as larger units on request.

General Data:

Voltage: 400 V (threephase current)
Frequency: 50 Hz

Subject to technical change!

 

TurboStar Mixer
Side wall installation


Spiral mixer FUCHS TURBOSTAR
Mounting on 3 floating devices

Floating device for spiral mixer FUCHS TURBOSTAR

Hanging framework for spiral mixer FUCHS TURBOSTAR



 
 

 

 


   
 
ISMA on water sevice ...
ISMA